Compressor Machine Humidifier Nebulizer is a drug delivery device used to medication in the form of a mist inhaled into the lungs . They can be used for medical treatment of the upper and lower respiratory tracts .

High/durable compressor :

running 2000 hours .Maximum pressure about 40 psi and 6 ~ 7 liters per minute

26 /30mmstamping with rising tempreture about 180 c.

1: Input:220V/50HZ 120V/60HZ

2: Power Consumption: 180VA

3: Medication Capacity: 6ml

4: Particle Size: Respirable Fraction 0.5 to 5μm 0.5μm80%

5: MMAD: 2.0μm

6: Average Nebulization Rate: Above 0.2ml/min.

7: Noise Level: Below 60 dBA

8: Compressor Pressure Range: 30-45 Psi

9: Operation Pressure Range: 12-14.5 Psi(0.85-1.1 bar)

10: Liter Flow Range: 8~ 10 lpm

11:Operation Temperature Range: 10°C--40°C (50°F--104°F)

12:Operation Humidity Range: 10 to 95% RH

13:Storage Temperature Range:-10°C--65°C

14:Storage Humidity Range: 10 to 95%RH

Medical atomizer is mainly used to treat various upper and lower respiratory diseases, such as cold, fever, cough, asthma, sore throat, pharyngitis, rhinitis, bronchitis, pneumoconiosis and other diseases in trachea, bronchus, alveoli and chest. Atomization inhalation therapy is an important and effective treatment method in the treatment of respiratory diseases. Atomization inhaler is used to atomize the drug solution into small particles, and the drug enters the respiratory tract and lungs through respiratory inhalation, so as to achieve the purpose of painless, rapid and effective treatment.

type

Ultrasonic atomizer: use the ultrasonic principle to atomize the liquid medicine.

Aerosol nebulizer has no selectivity to aerosol particles, so most of the particles produced can only be deposited on the upper respiratory tract such as the oral cavity and larynx. Moreover, because the amount of lung deposition is very small, it can not effectively treat the lower respiratory tract diseases. At the same time, due to the large fog particles and fast atomization produced by the ultrasonic atomizer, the patients inhale too much water vapor, humidifying the respiratory tract, and the dry and thick secretions in the respiratory tract that originally partially blocked the bronchus expand after absorbing water, increasing the resistance of the respiratory tract, which may produce the phenomenon of hypoxia, and the ultrasonic atomizer will make the drug liquid form water droplets and hang on the inner cavity wall, The effect on lower respiratory tract diseases is poor, the demand for drugs is large, resulting in waste.

Air compression atomizer

Air compression atomizer: also known as jet atomization, it uses compressed air to form a high-speed air flow through the small nozzle according to the venturi injection principle. The generated negative pressure drives the liquid or other fluids to spray onto the barrier, splashes around under the high-speed impact, and turns the droplets into mist particles to be ejected from the air outlet pipe.

The gas compression atomizer has the following advantages:

1. High efficiency oil-free piston compressor, no cooling water during atomization, daily maintenance free, simple and convenient operation; The original drug is atomized without dilution, and the clinical effect is good; Almost no drug residue and high drug utilization;

2. It is more convenient to operate and use. The product is equipped with a 2m air pipe with large room for movement. It can be used when sitting or lying down. The atomization component is light and convenient to wear and hold;

3. The atomization uses the original medicine atomization. The atomization amount inhaled within the relative treatment time is appropriate, which is not easy to cause the expansion of the mucous membrane of the inner wall of the trachea, resulting in the blockage of the trachea. The atomized particles are ultra-fine, and are not easy to collide and combine. The human body is comfortable to inhale, and can enter the trachea such as bronchus and lungs. The clinical effect is excellent, which is especially suitable for the treatment of lower respiratory tract diseases;

4. Pure mechanical products have extremely low failure rate, low maintenance cost and long service life. They are generally used normally for 5 ~ 10 years.

Net atomizer

Through the vibration of the vibrator, the liquid is extruded through the hole of the net type spray head of the nozzle, and is sprayed by tiny ultrasonic vibration and net type spray head structure.

Compressor machine humidifier nebulizer works the battery through air flow induction or key press to connect with the atomizer to generate heat, evaporate smoke oil and produce atomization effect, which is similar to that of smoking.

Hot Tags: compressor machine humidifier nebulizer, China, suppliers, manufacturers, factory